Topical note | Notes on carrying out repair work in the vehicle interior | ||
| Measure | ||
1 | Observe general information on chassis alignment. | ||
Also measure any tire wear. | |||
2 | Move vehicle onto wheel alignment measurement system. | ||
| 000 588 13 21 00 Wheel alignment system | ||
3 | Install brake pedal jack with adapter between brake pedal and driver's seat. | | |
A slight pressure on the brake pedal is sufficient. | |||
Brake pedal jack | |||
Adapter for brake pedal winch | |||
4 | Shift transmission into neutral or idle position. | ||
5 | Open window on driver's door for steering angle routine. | ||
6 | Switch off ignition. | Do not remove the transmitter key. Otherwise the steering wheel lock may engage. | |
7 | Close all doors and flaps as well as hoods. | Vehicle must remain clear of any load forces. | |
8 | Mount quick clamping device. | ||
9 | Attach measuring heads of wheel alignment measurement system. | ||
10 | Unlock turnplates and sliding plates. | ||
11 | Determine vehicle level at front and rear axle using electronic inclinometer. | ||
12 | Perform initial measurement. | ||
13 | Compare determined values with the specified values. | The caster on the front axle cannot be adjusted. | |
Permissible difference in caster between right and left side of vehicle | |||
Permissible difference in front axle camber between right and left side of vehicle | |||
Camber | |||
Permissible tolerance of individual toe-in | |||
Permissible difference in rear axle toe between right and left sides of vehicle | |||
Total toe | |||
Permissible difference in rear axle camber between right and left sides of vehicle | |||
Camber | |||
Permissible tolerance of individual toe-in | |||
Toe-out angle with 20° steering angle (inner wheel) | |||
Permissible difference in front axle toe between right and left sides of vehicle | |||
Total toe | |||
14 | Adjust toe on rear axle. | If required. | |
15 | Adjust camber on front axle. | If required. | |
16 | Adjust toe on front axle. | If required. | |
17 | Perform final measurement. | Print out data sheet. | |
18 | Detach measuring heads from wheel alignment measurement system. | ||
19 | Remove quick clamping devices. | ||
20 | Remove brake pedal jack and adapter. | ||
21 | Drive vehicle off the wheel alignment measurement system. | ||
22 | Lock turnplates and sliding plates. |
Front axle toe |
Number | Designation | Model 447 with engine 651, 654.9 with code ZG2 | Model 447, 448 with engine 274, | |||
BE40.20-N-1001-07KA | Total toe | at vehicle level | -5.10° | ° | -0° 06' ( 10') | -1°00' ( 10') |
-4.30° | ° | +0° 00' ( 10') | -0° 56' ( 10') | |||
-2.70° | ° | +0° 10' ( 10') | -0° 48' ( 10') | |||
-1.10° | ° | +0° 20' ( 10') | -0° 40' ( 10') | |||
+0.50° | ° | +0° 30' ( 10') | -0° 32' ( 10') | |||
+2.10° | ° | +0° 40' ( 10') | -0° 24' ( 10') | |||
+3.70° | ° | +0° 49' ( 10') | -0° 17' ( 10') | |||
+5.30° | ° | +0° 58' ( 10') | -0° 10' ( 10') | |||
+6.90° | ° | +1° 06' ( 10') | -0° 03' ( 10') | |||
+8.50° | ° | +1° 13' ( 10') | +0° 03' ( 10') | |||
+10.10° | ° | +1° 19' ( 10') | +0° 08' ( 10') | |||
+11.70° | ° | +1° 24' ( 10') | +0° 13' ( 10') | |||
+13.30° | ° | +1° 28' ( 10') | +0° 18' ( 10') |
Front axle toe |
Number | Designation | Model 447 with engine 622 | Model 447 with engine 780.702 | |||
BE40.20-N-1001-07KA | Total toe | at vehicle level | -5.10° | ° | -1° 22' ( 10') | -1° 18' ( 10') |
-4.30° | ° | -1° 13' ( 10') | -1° 09' ( 10') | |||
-2.70° | ° | -0° 57' ( 10') | -0° 51' ( 10') | |||
-1.10° | ° | -0° 42' ( 10') | -0° 36' ( 10') | |||
+0.50° | ° | -0° 27' ( 10') | -0° 21' ( 10') | |||
+2.10° | ° | -0° 14' ( 10') | -0° 08' ( 10') | |||
+3.70° | ° | -0° 02' ( 10') | +0° 04' ( 10') | |||
+5.30° | ° | +0° 09' ( 10') | +0° 15' ( 10') | |||
+6.90° | ° | +0° 19' ( 10') | +0° 25' ( 10') | |||
+8.50° | ° | +0° 29' ( 10') | +0° 35' ( 10') | |||
+10.10° | ° | +0° 38' ( 10') | +0° 43' ( 10') | |||
+11.70° | ° | +0° 47' ( 10') | +0° 52' ( 10') | |||
+13.30° | ° | +0° 56' ( 10') | +1° 00' ( 10') |
Rear axle camber |
Number | Designation | Model 447 with engine 274, 651, 654.9 | Model 447 with engine 622 | |||
BE40.20-N-1001-09Q | Camber | at vehicle level | +7.92° | ° | +0° 56' ( 1°) | -2° 00' ( 1°) |
+6.92° | ° | +0° 47' ( 1°) | -1° 52' ( 1°) | |||
+6.14° | ° | +0° 40' ( 1°) | -1° 47' ( 1°) | |||
+5.35° | ° | +0° 33' ( 1°) | -1° 41' ( 1°) | |||
+4.57° | ° | +0° 25' ( 1°) | -1° 35' ( 1°) | |||
+3.78° | ° | +0° 18' ( 1°) | -1° 29' ( 1°) | |||
+3.00° | ° | +0° 11' ( 1°) | -1° 23' ( 1°) | |||
+2.21° | ° | +0° 04' ( 1°) | -1° 17' ( 1°) | |||
+1.43° | ° | -0° 03' ( 1°) | -1° 11' ( 1°) | |||
+0.64° | ° | -0° 10' ( 1°) | -1° 05' ( 1°) | |||
+0.14° | ° | -0° 14' ( 1°) | -1° 01' ( 1°) | |||
-0.93° | ° | -0° 24' ( 1°) | -0° 53' ( 1°) | |||
-1.71° | ° | -0° 30' ( 1°) | -0° 47' ( 1°) | |||
-2.50° | ° | -0° 37' ( 1°) | -0° 40' ( 1°) | |||
-3.28° | ° | -0° 44' ( 1°) | -0° 34' ( 1°) | |||
-4.07° | ° | -0° 51' ( 1°) | -0° 28' ( 1°) | |||
-4.85° | ° | -0° 57' ( 1°) | -0° 22' ( 1°) | |||
-5.64° | ° | -1° 04' ( 1°) | -0° 15' ( 1°) | |||
-6.74° | ° | -1° 13' ( 1°) | -0° 06' ( 1°) |
Rear axle toe |
Number | Designation | Model 447 with engine 274, 651, 654.9 | Model 447 with engine 622 | |||
BE40.20-N-1001-10Q | Total toe | at vehicle level | +7.92° | ° | -0° 40' (+20'/-12') | +2° 08' (+20'/-12') |
+6.92° | ° | -0° 35' (+20'/-12') | +1° 57' (+20'/-12') | |||
+6.14° | ° | -0° 31' (+20'/-12') | +1° 49' (+20'/-12') | |||
+5.35° | ° | -0° 27' (+20'/-12') | +1° 41' (+20'/-12') | |||
+4.57° | ° | -0° 22' (+20'/-12') | +1° 33' (+20'/-12') | |||
+3.78° | ° | -0° 17' (+20'/-12') | +1° 26' (+20'/-12') | |||
+3.00° | ° | -0° 13' (+20'/-12') | +1° 18' (+20'/-12') | |||
+2.21° | ° | -0° 07' (+20'/-12') | +1° 11' (+20'/-12') | |||
+1.43° | ° | -0° 02' (+20'/-12') | +1° 05' (+20'/-12') | |||
+0.64° | ° | +0° 03' (+20'/-12') | +0° 57' (+20'/-12') | |||
+0.14° | ° | +0° 07' (+20'/-12') | +0° 52' (+20'/-12') | |||
-0.93° | ° | +0° 15' (+20'/-12') | +0° 43' (+20'/-12') | |||
-1.71° | ° | +0° 21' (+20'/-12') | +0° 37' (+20'/-12') | |||
-2.50° | ° | +0° 28' (+20'/-12') | +0° 31' (+20'/-12') | |||
-3.28° | ° | +0° 35' (+20'/-12') | +0° 25' (+20'/-12') | |||
-4.07° | ° | +0° 41' (+20'/-12') | +0° 19' (+20'/-12') | |||
-4.85° | ° | +0° 49' (+20'/-12') | +0° 13' (+20'/-12') | |||
-5.64° | ° | +0° 56' (+20'/-12') | +0° 08' (+20'/-12') | |||
-6.74° | ° | +1° 07' (+20'/-12') | +0° 01' (+20'/-12') |
Front axle camber |
Number | Designation | Model 447 with engine 651, 654.9 with code ZG2 | Model 447 with engine 274 except code CF8, | |||
BE40.20-N-1001-13Y | Camber | at vehicle level | -5.10° | ° | -0° 56' ( 19') | -1° 10' ( 19') |
-4.30° | ° | -0° 52' ( 19') | -1° 12' ( 19') | |||
-2.70° | ° | -0° 43' ( 19') | -1° 15' ( 19') | |||
-1.10° | ° | -0° 32' ( 19') | -1° 16' ( 19') | |||
+0.50° | ° | -0° 19' ( 19') | -1° 16' ( 19') | |||
+2.10° | ° | -0° 05' ( 19') | -1° 15' ( 19') | |||
+3.70° | ° | +0° 11' ( 19') | -1° 12' ( 19') | |||
+5.30° | ° | +0° 28' ( 19') | -1° 08' ( 19') | |||
+6.90° | ° | +0° 46' ( 19') | -1° 03' ( 19') | |||
+8.50° | ° | +1° 06' ( 19') | -0° 57' ( 19') | |||
+10.10° | ° | +1° 27' ( 19') | -0° 50' ( 19') | |||
+11.70° | ° | +1° 50' ( 19') | -0° 41' ( 19') | |||
+13.30° | ° | +2° 13' ( 19') | -0° 32' ( 19') |
Front axle camber |
Number | Designation | Model 447 with engine 274 with code CF8, | Model 447 with engine 622, | |||
BE40.20-N-1001-13Y | Camber | at vehicle level | -5.10° | ° | -0° 55' ( 19') | -0° 40' ( 19') |
-4.30° | ° | -0° 57' ( 19') | -0° 42' ( 19') | |||
-2.70° | ° | -1° 00' ( 19') | -0° 43' ( 19') | |||
-1.10° | ° | -1° 01' ( 19') | -0° 43' ( 19') | |||
+0.50° | ° | -1° 01' ( 19') | -0° 42' ( 19') | |||
+2.10° | ° | -1° 00' ( 19') | -0° 38' ( 19') | |||
+3.70° | ° | -0° 57' ( 19') | -0° 34' ( 19') | |||
+5.30° | ° | -0° 53' ( 19') | -0° 28' ( 19') | |||
+6.90° | ° | -0° 48' ( 19') | -0° 20' ( 19') | |||
+8.50° | ° | -0° 42' ( 19') | -0° 11' ( 19') | |||
+10.10° | ° | -0° 35' ( 19') | -0° 02' ( 19') | |||
+11.70° | ° | -0° 26' ( 19') | +0° 10' ( 19') | |||
+13.30° | ° | -0° 17' ( 19') | +0° 22' ( 19') |
Front axle camber |
Number | Designation | Model 447 with engine 780.702 | |||
BE40.20-N-1001-13Y | Camber | at vehicle level | -5.10° | ° | -0° 46' ( 19') |
-4.30° | ° | -0° 47' ( 19') | |||
-2.70° | ° | -0° 47' ( 19') | |||
-1.10° | ° | -0° 45' ( 19') | |||
+0.50° | ° | -0° 41' ( 19') | |||
+2.10° | ° | -0° 36' ( 19') | |||
+3.70° | ° | -0° 28' ( 19') | |||
+5.30° | ° | -0° 19' ( 19') | |||
+6.90° | ° | -0° 08' ( 19') | |||
+8.50° | ° | +0° 04' ( 19') | |||
+10.10° | ° | +0° 17' ( 19') | |||
+11.70° | ° | +0° 32' ( 19') | |||
+13.30° | ° | +0° 48' ( 19') |
Front axle camber |
Number | Designation | Model 447 with engine 651, 654.9 with code ZG2 | Model 447 with engine 274 except code CF8, | |
BE40.20-N-1002-13Y | Permissible difference in front axle camber between right and left side of vehicle | ° | 19' | 19' |
Front axle camber |
Number | Designation | Model 447 with engine 274 with code CF8, | Model 447 with engine 622, | |
BE40.20-N-1002-13Y | Permissible difference in front axle camber between right and left side of vehicle | ° | 19' | 19' |
000 589 18 31 00
Brake pedal jack
211 589 00 31 00
Adapter for brake pedal winch