Shown on model 910.6, right side of vehicle |
1 | B-pillar outer section |
D63.20-1505-05
Shown on model 907 except code EL9 (2-way front and rear speaker system) and except code FY2 (Double lock) and except code T51 (Electric closing assist for left sliding door) and except code T56 (Electrical actuation for left sliding door), left side of vehicle |
1 | B-pillar outer section |
2 | Fuel filler flap |
3 | Filler neck |
4 | Lower guide rail |
5 | Front door sill trim |
6 | Protective strip |
7 | Frame seal |
8 | Frame seal |
9 | Lock striker |
10 | Contact plate |
11 | Guide bearing |
12 | Bolts |
13 | Bolts |
D60.00-A011-06
Shown on model 907, right side of vehicle |
17 | Electrical wiring harness |
D60.00-A032-12
Danger | Risk of death when working on component parts and systems with U >= 30 V alternating voltage (AC) or U >= 60 V direct voltage (DC) | Do not touch damaged or defective live component parts and lines or non-insulated electrical connections and lines.Typ 910.6 mit Motor 780.703 | |
Danger | Risk of death caused by vehicle slipping or toppling off of the lifting platform. | Align vehicle between vehicle lift columns and position the four support plates at the vehicle lift support points specified by the vehicle manufacturer. | |
Topical note | Notes on battery | Typ 910.6 mit Motor 780.703 | |
Topical note | General information on vehicles with high-voltage on-board electrical system and/or lithium-ion battery and/or gaseous-fuel drive system as well as personal protective equipment | Typ 910.6 mit Motor 780.703 | |
Topical note | Notes on carrying out repair work in the vehicle interior | ||
| Remove/install | ||
1 | Remove respective hinge of front door. | ||
2 | Remove respective sliding door. |
| |
Model 907.6/7 with code T55 (Electrical actuation for right sliding door) or code T56 (Electrical actuation for left sliding door) | |||
3 | Remove respective lower guide rail (4). |
| |
4 | Remove fuel filler flap (2). | If left side of vehicle is damaged. | |
Model 910.6 with engine 651, model 907.6/7 | |||
5 | Remove filler neck (3). | If left side of vehicle is damaged. | |
Model 907.6 with engine 654.9, Model 907 with engines 642, 651, Model 910 with engine 651 | |||
Model 907.6/7 with engine 274 | |||
6 | Remove upper trim from partition. |
| |
7 | Remove lower trim from partition. |
| |
8 | Remove respective front door sill trim (5). | ||
9 | Remove trim from respective sliding door entrance step module. |
| |
Model 907.6 with code V39 (Plastic floor for people mover), model 907.6 with code VK8 (Plastic floor covering) | |||
10 | Remove front partition. | Model 907.6, 910.6 with code D50 (full-width partition wall) or with code D51 (full-width partition wall with 1 window) or with code D64 (partition with sliding door) | |
Model 910.6 with code D50 (full-width partition wall) or code D51 (full-width partition wall with 1 window) | |||
Model 907.6 with code D50 (full-width partition wall) or code D51 (full-width partition wall with 1 window) | |||
Model 907.6, 910.6 with code D64 (Partition with sliding door) | |||
11 | Remove respective protective strip (6). | ||
12 | Remove respective sealing frame (7) in the repair area and position outside the working area. | ||
13 | Remove respective sealing frame (8) in the repair area and position outside the working area. | ||
14 | Remove respective seat belt from B-pillar. | ||
15 | Remove respective electrical wiring harness (17) in the repair area and position outside the working area. | ||
16 | Remove front roof lining. | ||
17 | Remove center roof lining. |
| |
18 | Remove respective lock striker (9). | Bolt, lock striker to B-pillar | |
19.1 | Remove respective contact plate (10). | Model 907.6/7 except code EL9 (2-way front and rear speaker system) except code FY2 (Double lock) except code T50 (Electric closing assist for right sliding door) except code T55 (Electrical actuation for right sliding door), right side of vehicle, Model 907.6/7 except code EL9 (2-way front and rear speaker system) except code FY2 (Double lock) except code T51 (Electric closing assist for left sliding door) except code T56 (Electrical actuation for left sliding door), left side of vehicle, Model 910.6 | |
To do so, unscrew screws/bolts (13). | |||
19.2 | Remove respective cover from B-pillar. | Model 907.6/7 with code EL9 (2-way front and rear speaker system), Model 907.6/7 with code FY2 (Double lock), Model 907.6/7 with code T50 (Electric closing assist for right sliding door), right side of vehicle, Model 907.6/7 with code T55 (Electrical actuation for right sliding door), right side of vehicle, Model 907.6/7 with code T51 (Electric closing assist for left sliding door), left side of vehicle, Model 907.6/7 with code T56 (Electrical actuation for left sliding door), left side of vehicle | |
To do this, unscrew screws/bolts. | |||
20 | Remove respective guide bearing (11). | To do so, remove screws/bolts (12). | |
Striker pin to B-pillar | |||
21 | Remove respective underfloor paneling. |
| |
22 | Remove HV battery module. | * Applies to Europe only | |
Model 910.6 with engine 780.703 | |||
23 | Install in the reverse order. |
Powiązane dokumenty
- ah0000z030001a Ogólne wskazówki dotyczące pojazdów z instalacją wysokiego napięcia i/lub akumulatorem litowo-jonowym i/lub gazowym systemem napędu oraz osobistego wyposażenia ochronnego
- ah5410p000101a
- ah5410p000101a Wskazówki dotyczące akumulatora
- ah6800n000101s Wskazówki dotyczące wykonywania prac naprawczych we wnętrzu pojazdu
- ar4710d7541ts
- ar4710d7541tsc
- ar4770d0001te
- ar6130d1001ts
- ar6830d0018tsb
- ar6830d0018tsr
- ar6830d1306ts
- ar6830d1407ts
- ar6830d1408ts
- ar6830d7607ts
- ar6830d7609tsr
- ar6874d0700tsf
- ar6874d0700tsr
- ar7210d2662ts
- ar7216d1260ts
- ar7216d1260tsb
- ar7216d7816ts
- ar8860d6023ts
- ar8880d1040ts
- ar9140d1015ts
- as0000z001001a Zagrożenie życia na skutek ześlizgnięcia lub spadnięcia pojazdu z podnośnika.
- as0000z003501a Zagrożenie życia podczas prac przy elementach i systemach U >=30 V napięcie zmienne (AC) bądź U >=60 V napięcie zmienne