AR46.30-T-0010B | Fill power steering pump and bleed | 21.3.00 |
Steering 765.860 in MODEL NMB613.355 /358 /388 /455 /485
Steering 766.376 in MODEL NMB613.358 /388
T46.30-0002-09
1 Starter button
2 Engine stop button
A Maximum marking
B Cover
C Steering oil reservoir
1 | Position vehicle on turntables | The vehicle may only be driven up onto turnplates secured as per the manufacturer's specifications. | |
2 | Open engine compartment flap | See Operating Instructions | |
3 | Unscrew cap (B) of steering oil reservoir (C) | When filling the steering system with steering gear oil there is the risk that dirt will get into the steering circuit. Pay attention to the greatest cleanliness when filling up and refilling, in order to avoid malfunctions due to foreign matter in the steering circuit. | |
4 | Replace filter cartridge in the steering oil reservoir (C) | Only required during repair work carried out on the steering circuit. | |
5 | Fill steering oil reservoir (C) | Fill steering gear oil up to the upper edge of the steering oil reservoir (C). | |
| Steering gear oils (ATF) | Sheet 236.3 | |
Danger! | Risk of accident caused by vehicle starting off by itself when engine is running. Risk of injury caused by contusions and burns when working in engine during starting procedure | Secure vehicle to prevent it from moving. | |
6 | Start engine | When the engine compartment flap is open the engine can only be started with the starter push button (1) in the engine compartment. | |
7 | Refill the steering gear oil in the steering oil reservoir (C) | If the oil level in the steering oil reservoir (C) no longer drops under the maximum mark (A), allow the engine to idle for 2 to 3 minutes. | |
8 | Turn the steering at the steering wheel 5 to 6 times from steering lock to steering lock | Turn up to the steering stop with only a slight force. | |
9 | Check oil level in steering oil reservoir (C) | ||
| Power steering - checking and correcting oil level | ||
10 | Turn off engine | With correct ventilation of the steering circuit the oil level in the steering oil reservoir (C) must not rise more than 1 to 2 cm. | |
11 | Screw on cover (B) of the steering oil reservoir (C) | ||
12 | Close engine compartment flap | See Operating Instructions | |
13 | Drive vehicle off the turnplates | Before driving the vehicle down off the turnplates they must be secured as per the manufacturer's specifications. |
Referenced documents
- ap4600t4611a Check and correct power steering oil level
- ar0060t200001b Position vehicle on turnplates
- ar4625t100001b Remove/install cartridge in oil sump
- as0000z000501a Risk of accident from vehicle starting off by itself when engine running. Risk of injury (bruises and burns) resulting from working on the engine while it is being started or when it is running.
- bb0040p023603a Steering gear oils (ATF) (specification 236.3)