Operation no. of the operation texts or standard texts and flat rates | |||||
Category | Op. no. | Operation text | Time | Acc. no. | Code |
N | 028676 | Check electrical connections | 1,1 h | 54 918 51 | KONTAKT |
N | 028677 | Check female contact (additional 10) (after check) | 0,1 h | 54 918 51 | KONTAKT |
N | 028678 | Check female contact (additional 5) (after check) | 0,1 h | 54 918 51 | KONTAKT |
N | 028682 | Remove/install operating unit for heater (after check) | 0,7 h | 54 918 51 | KONTAKT |
1 | Contact receptacles |
2 | Electrical connector |
3 | Adapter cable |
W54.18-1199-06
| Remove | ||
1 | Disconnect battery ground line | ||
| |||
2 | Open maintenance flap | ||
3 | Remove outer cover on electronics compartment | ||
4 | Remove passenger-side trim in footwell | ||
5 | Remove air duct in passenger-side footwell | ||
6 | Remove tachograph | ||
| |||
| |||
7 | Remove master switch module 4 (A68) | ||
| |||
8 | Remove heating control and operating unit | Only for vehicles with code H03 (A/C), or with code H07 (AAC), or with code H65 (Auxiliary water heater "Webasto"Thermo Top 90), or right-hand drive vehicles. | |
9 | Remove footwell cover on driver side | ||
| |||
10 | Remove side trim from instrument panel | ||
| Check | ||
11 | Check female contact (1) of electrical connection (2), replace if necessary | ||
| Adapter cable for checking an electrical connection | ||
If there is no mechanical resistance when inserting the adapter cable (3) into the female contact (1) to be checked: | |||
| |||
Replace female contact (1). | |||
If there is a mechanical resistance when inserting the adapter cable (3) into the female contact (1) to be checked: | |||
| |||
Female contact (1) OK. | |||
| Install | ||
12 | Install side trim onto instrument panel | ||
13 | Install footwell cover on driver's side | ||
| |||
14 | Install heating control and operating unit | Only for vehicles with code H03 (A/C), or with code H07 (AAC), or with code H65 (Auxiliary water heater "Webasto"Thermo Top 90), or right-hand drive vehicles. | |
15 | Install master switch module 4 (A68) | ||
| |||
16 | Install tachograph | ||
| |||
| |||
17 | Install air duct for passenger-side footwell | ||
18 | Install passenger-side trim in footwell | ||
19 | Install cover above electronics compartment | ||
20 | Close maintenance flap | ||
21 | Connect ground cable to battery | ||
|