PE54.10-W-2000-60AB | Legend of wiring diagram of battery, voltage supply | Models 970, 972, 974, 975, 976 as of 1.5.00 up to 28.2.03 |
Code | Designation | Coordinate |
A1 | Daytime running lamp control unit | 56M |
A3 | FR/FMR control unit | 9M 26M 33M 50M |
A4 | Flame starting system control unit | 47M |
A5 | GGVS control unit | 24A 36A |
A6 | MR/PLD control unit | 7M 25M |
A7 | Base module | 8M 15M 31M 39M 45M 64M 67M |
A23 | CL/CLS control unit | 41M |
A31 | Warm air heater | 41M 52M |
A33 | Retarder control unit (Telma) | 5M |
A38 | Convenience locking system control unit | 42M |
A42 | WSP control unit | 27M |
F1S i1 | Radio/voltage converter (small)/cab illumination/diagnostic socket/radio remote control fuse, circuit 30 (base module) | 67L |
F15Si15 | Instrument illumination/switch illumination fuse, circuit 58 (base module) | 38L 64L |
F21Si21 | Instrument/stop lamp/backup lamp fuse, circuit 15 (base module) | 15L |
F30 | Relay D+/tail lift/Racor filter fuse, circuit 30 (fuse holder A3) | 49L |
F42 | Large voltage transformer fuse, circuit 30 (fuse holder A2) | 65L |
F48 | Engine tunnel 12V socket fuse, circuit 30 (fuse holder A2) | 62I |
F71 | Retarder (Telma) fuse, terminal 30 | 4H |
F72 | Tail lift/ancillary consumer fuse, circuit 30 | 3H |
G1 | Battery | 2G 2I 20G 20I |
G2 | Alternator | 9E |
G3 | Additional alternator | 13E |
G6 | Compact alternator | 14F |
J5 | Cable weld connector, to A7, A9, A46, K38, K39, S45, S47 (without CL/CLS), S48 (without CL/CLS), T2, X13-14/3, X18.1-18/1, X26-18/6, X63-18/2 | 67I |
J12 | Cable weld connector, to A59, A60, T2, X18.1-18/17, X37-26/4, X63-18/4, X63-18/6, X63-18/11, X117-4/1 | 71G |
J13 | Cable weld connector, to A59, A60, F46, K41, K51, K66, X18.1-18/16, X18.2-18/1, X37-26/8, | 72H |
J18 | Cable weld connector, to F30, K5, X56-18/13 | 49F |
J40 | Cable weld connector, to W2 | 45L 63L 68I |
J41 | Cable weld connector, to J49/W2.1 | 51I |
J42 | Cable weld connector, to W6 | 60L |
J43 | Cable weld connector, to W3 | 24L 58L |
J49 | Cable weld connector, to W2.1 | 51L |
J52 | Cable weld connector, to A3, A42, K24, X2.1-18/2, X47-18/5 | 24F |
J58 | Cable weld connector, to A1, A31, K4, K5, K42, X5.1-18/1, X22.1-12/3, X23.1-12/5, X83-6/5 | 53I |
K2 | Battery disconnect switch | 22E |
K4 | Compressed air drier heater relay | 57M |
K5 | D+ relay (relay holder L1) | 51F |
K8 | Circuit 15 relay | 45F |
K24 | Drive control/engine control/circuit 15 relay | 28H |
K41 | Communication preinstallation 1 relay (relay holder L2) | 74K |
K42 | Oil cooling pump relay | 54M |
K51 | Communication preinstallation 2 relay (relay holder L1) | 73K |
M1 | Starter | 5H |
M9 | Driver-side mirror adjustment motor | 55B |
M10 | Front passenger-side mirror adjustment motor | 58B |
P1 | Tachograph | 13M 22M |
P2 | Instrument | 40M |
R2 | Tachograph current limiter | 23G |
R4 | Driver-side mirror heater | 53B |
R5 | Front passenger-side mirror heater | 56B |
R14 | Racor filter heater | 58H |
S1.1 | GGVS drive switch | 31H |
S5 | Cab EMERGENCY OFF switch | 35G |
S6.3 | EMERGENCY OFF switch at right of frame | 36F |
S71 | 12V socket switch | 61E |
S102 | Tail lift main switch | 3L |
S121 | Reset switch (GGVS France) | 17G |
T1 | Large 24/12V voltage converter | 61H |
T2 | Small 24/12V voltage converter | 71C |
V2 | Circuit 49 diode | 38F |
V3 | Circuit 58 diode | 39F |
V4 | Auxiliary heater diode | 40F |
V5 | CL/CLS diode | 42F |
V8 | Cutoff delay diode | 39F |
W2 | Ground point circuit 31 cab front passenger footwell (at cab-chassis plug connections) | 46M 63M 68M |
W2.1 | Ground point circuit 31 cab front passenger footwell (at cab-chassis plug connections) | 51M |
W3 | Ground point, circuit 31, engine (in frame behind right front axle ABS solenoid valve) | 2M 10M 13M 20M 24M 58M |
W6 | Ground point, circuit 31, steering column bearing bracket | 60M |
XB.15 | Cable weld point circuit 15 middle of cab waistrail (at front passenger cigar lighter) | 46I |
XB.30 | Cable weld point circuit 30 in middle of cab waistrail (at 2nd radio slot and AC anti-icing switch) | 43I |
XB.31 | Cable weld point circuit 31 center of cab waistrail (at hazard flasher switch/driver ashtray) | 62I |
XB.58 | Cable weld point, circuit 58, middle of cab waistrail | 38I 64I |
XQ.31.2 | Cable weld point circuit 31 (at fuel tank) | 23K 58K |
X2.1 | Cab-chassis connector | 12G 15G 17G 25I |
X5.1 | Cab-chassis connector | 57F |
X6.1 | Cab-chassis connector | 15I |
X18.1 | Roof connector | 69I 70I |
X22.1 | Driver door connector | 53F |
X23.1 | Passenger door connector | 56F |
X27 | 12V engine tunnel socket | 61M |
X37 | Radio connector | 71M |
X45 | Two-way radio connector | 69M |
X47 | Cab-chassis connector | 21I 22I 24G 29D 33D 35D 36I 38D |
X55 | Tail lift connector | 50M |
X56 | Cab-chassis connector | 49I |
X63 | Telephone/fax/channel group communication/Telematic connector | 75M |
X79 | Power socket | 1M |
X83 | Voltage connection (body manufacturer) | 53M |
Y62 | Engine brake flap solenoid valve (with GGVS) | 24I |
(138) | With GGVS | 5B 18L 53G 56G |
(350) | optionally depending on version | 4D 7D 8I 10I 12I 18D 18K 41H |
(440) | only with GGVS France | 17E 36E |
(473) | to ancillary consumers (body manufacturer) | 3M |
(474) | Circuit 15 relay (for special versions) | 43L |
(476) | D+ relay | 48L |
(501) | Voltage converter | 59L |